Nissan warns owners of older vehicles not to drive them due to risk of exploding air bag inflators
By TOM KRISHER
AP Auto Writer
DETROIT (AP) — Nissan is urging the owners of about 84,000 older vehicles to stop driving them because their Takata air bag inflators have an increased risk of exploding in a crash and hurling dangerous metal fragments.
Wednesday’s urgent request comes after one person in a Nissan was killed by an exploding front-passenger inflator, and as many as 58 people were injured since 2015.
“Due to the age of the vehicles equipped with defective Takata air bag inflators, there is an increased risk the inflator could explode during an air bag deployment, propelling sharp metal fragments which can cause serious injury or death,” Nissan said in a statement.
Nissan said the “do not drive” warning covers certain 2002 through 2006 Sentra small cars, as well as some 2002 through 2004 Pathfinder SUVs, and 2002 and 2003 Infiniti QX4 SUVs. Owners can find out if their vehicles are affected by going to nissanusa.com/takata-airbag-recall or infinitiusa.com/takata-airbag-recall and keying in their 17-digit vehicle identification number.
The company says owners should contact their dealer to set up an appointment to have inflators replaced for free. Nissan also is offering free towing to dealers, and in some locations mobile service and loaner cars are available.
Nissan originally recalled 736,422 of the vehicles to replace the Takata inflators. The company said around 84,000 remain unrepaired and are believed to still be in use.
Nissan said it has made numerous attempts to reach the owners with unrepaired Takata inflators.
The death was reported to the U.S. National Highway Traffic Safety Administration in 2018, the company said. The person killed was in a 2006 Sentra, according to Nissan.
The death is one of 27 in the U.S. caused by the faulty inflators, which used volatile ammonium nitrate to create a small explosion to inflate air bags in a crash. The chemical can deteriorate over time when exposed to high temperatures and humidity. It can explode with too much force, blowing apart a metal canister and spewing shrapnel. More than 400 people in the U.S. have been hurt.
Worldwide at least 35 people have been killed by Takata inflators in Malaysia, Australia and the U.S.
Potential for a dangerous malfunction led to the largest series of auto recalls in U.S. history, with at least 67 million Takata inflators involved. The U.S. government says many have not been repaired. About 100 million inflators have been recalled worldwide. The exploding air bags sent Takata into bankruptcy.
Honda, Ford, BMW, Toyota and Stellantis and Mazda have issued similar “do not drive” warnings for some of their vehicles equipped with Takata inflators.
